快速卷帘门的组成有哪些？_行业新闻_新闻资讯-Z6尊龙官方网站官网入口

行业新闻

首页>>新闻资讯>>行业新闻快速卷帘门的组成有哪些？

行业新闻

新闻资讯

联系Z6尊龙官方网站官网入口

Z6尊龙官方网站官网入口

联系人：林经理

电话：151 6888 2846

邮箱：527800164@qq.com

地点：济南市历下区化纤厂路8号3号楼101号

快速卷帘门的组成有哪些？

来源：日期：2023-07-31 宣布人：

1、顶部结构

1. Top structure

快速卷帘门的传动机构装置在门洞顶部机箱内，机箱由厚2mm厚镀锌钢板制作而成两端端由厚6mm钢板制作，在端板上设有装置卷轴轴承，驱动电机，平衡系统构件的装置座和装置孔，钢板外貌经喷塑处理成客户要求的色彩。卷轴装置于机箱内，由卷筒、轴端、轴承座等组成。卷筒尺寸凭据门洞高、宽尺寸经过盘算，选择合理尺寸，在这个门上，卷筒直径为219mm。

The transmission mechanism of the fast Roller shutter is installed in the box at the top of the door opening. The box is made of 2mm thick galvanized steel plate. Both ends of the box are made of 6mm thick steel plate. The end plate is equipped with mounting seats and mounting holes for installing reel bearings, driving motors, and balancing system components. The surface of the steel plate is sprayed with plastic to become the color required by customers. The reel is installed inside the chassis and consists of a drum, shaft end, bearing seat, etc. The size of the drum is calculated based on the height and width of the door opening, and a reasonable size is selected. On this door, the diameter of the drum is 219mm.

2、导槽箱

2. Guide box

导槽箱由厚2mm镀锌钢板制作，立于门洞二侧牢固于墙面，机箱则置于导槽箱顶部通过螺栓与导槽箱及墙面牢固。导槽箱导槽二侧牢固有密封毛条，以包管一定的密封要求，在导槽箱的底部离地约1m高位置，则预留有红外线监测器的装置位置�？焖倬砹泵诺牡疾巯渚缢艽�，与机箱同色，导槽里部的毛刷抵住帘布以限制帘布不会脱离导槽，这样当车子撞到门的时候，门帘会脱离导槽，从而制止快速卷帘门体受到损坏。

The guide box is made of 2mm thick galvanized steel plate, standing on both sides of the door opening and fixed to the wall. The chassis is placed on the top of the guide box and fixed to the guide box and wall with bolts. There are sealing strips fixed on both sides of the guide groove of the guide groove box to ensure certain sealing requirements. At the bottom of the guide groove box about 1m above the ground, there is a reserved installation position for the infrared monitor. The guide slot box of the fast Roller shutter is sprayed with plastic and is the same color as the box. The brush in the guide slot is against the cord fabric to limit the cord fabric from leaving the guide slot. In this way, when the car hits the door, the curtain will leave the guide slot, so as to avoid damage to the fast Roller shutter body.
济南卷帘门

3、帘布

3. Cord fabric

快速卷帘门的帘布可分段制作，每段高度约为700mm左右，各段帘布通过特制的铝质抗风条联接成一整体帘布，具有强度高、抗攻击、不易刺穿等优点。别的，我们还可选用透明PVC质料制作帘布或部份选用透明PVC质料制作帘布，以便视察软帘门二侧的情况，在帘布的底部设有铝质底梁，及防撞软袋帘布的顶部通过螺钉和压条牢固在卷筒上。

The cord fabric of the fast Roller shutter can be made in sections, each section of which is about 700mm high. Each section of cord fabric is connected into a whole cord fabric through a specially made aluminum wind resistant strip, which has the advantages of high strength, impact resistance, and puncture resistance. In addition, we can also use transparent PVC material to make the curtain or partially use transparent PVC material to make the curtain, in order to observe the situation on both sides of the soft curtain door. There is an aluminum bottom beam at the bottom of the curtain, and the top of the anti-collision soft bag curtain is fixed to the drum through screws and pressure strips.

4、驱动装置

4. Drive device

通过减速马达直接驱动软帘门转轴，凭据快速卷帘门提升速度的要求选用差别速比的减速器，抵达所要求的提升速度，快者速度可抵达80cm/s以上�？刂葡呗方幽杀淦悼刂�，使帘布运行时做到缓起动缓停止，并可使帘布到位自停，及在运行历程中停止运动。

The shaft of the soft shutter is directly driven by the deceleration motor. According to the requirements of the lifting speed of the fast Roller shutter, different speed ratio reducers are selected to achieve the required lifting speed, which can reach more than 80cm/s. The control circuit adopts variable frequency control to achieve slow start and slow stop during the operation of the cord fabric, and can automatically stop the cord fabric in place and stop its movement during operation.

5、控制系统

5. Control system

快速卷帘门设有控制箱，可在控制箱操作“开”、“停”、“关”，并可在控制箱的另一侧墙面设控制按钮操作“开”、“停”、“关”�？焖倬砹泵趴善揪菪枰∨湟？夭僮骱屠状锾讲饣虻卮鸥杏ψ远孛�，在门洞二侧设有红外线监测装置，当门体运动时有障碍物穿越门洞时，帘布运动将停止，或回复到开门状态。

The fast Roller shutter is equipped with a control box, which can operate "open", "stop" and "close", and a control button can be set on the other side of the wall of the control box to operate "open", "stop" and "close". The quick Roller shutter can be equipped with remote control operation, radar detection or geomagnetic induction automatic door opening and closing as required. The infrared monitoring device is set on both sides of the door opening. When an obstacle passes through the door opening when the door body is moving, the movement of the curtain will stop or return to the open state.

下一篇：电动卷帘门的特点有哪些？上一篇：双层铝合金门的一些基础信息了解